§ 141.13. Inspection of certain boilers and pressure vessels
Oklahoma Statutes AnnotatedTitle 40. LaborEffective: November 1, 2018
Effective: November 1, 2018
40 Okl.St.Ann. § 141.13
§ 141.13. Inspection of certain boilers and pressure vessels
A. The Commissioner of Labor or the chief boiler inspector, or any deputy inspector, shall have free access, during reasonable hours, to any premises in the state where a boiler or pressure vessel is being constructed for use in, or is being installed in this state for the purpose of ascertaining whether such boiler or pressure vessel is being constructed and installed in accordance with the provisions of the Boiler and Pressure Vessel Safety Act.
1. Power boilers and high pressure high temperature water boilers shall receive an inspection annually which shall be an internal inspection where construction permits; otherwise it shall be as complete an inspection as possible. Such boilers shall also be externally inspected annually preferably while under pressure;
5. Pressure vessels, excluding those within the scope of the American Petroleum Institute Pressure Vessel Inspection Code, subject to internal corrosion and waste heat steam generators shall receive an internal inspection triennially where construction permits. Pressure vessels not subject to internal corrosion shall receive an inspection at intervals set by the Commissioner. Frequency of external inspections of pressure vessels shall be set by the Commissioner;
6. A grace period of two (2) months beyond the periods specified in paragraphs 1, 2, 3, 4 and 5 of this subsection is permitted between inspections; however, the inspection due date shall not be affected; provided, however, for an entity with two or more boilers or pressure vessels, the Commissioner may allow all inspections of the boilers or pressure vessels to be conducted at that location at the same time;
8. Under the provisions of the Boiler and Pressure Vessel Safety Act, the Commissioner of Labor is responsible to provide rules for the safety of life, limb and property and therefore has jurisdiction over the interpretation and application of the inspection requirements as provided for in the rules. Inspection during construction and installation shall certify as to the minimum requirement for safety as defined in the American Society of Mechanical Engineers Code or other construction standards acceptable to the Commissioner of Labor. Inspection requirements of operating equipment shall be in accordance with generally accepted practice and compatible with the actual service condition, such as:
Based upon the documentation of such actual service conditions by the owner or user of the operating equipment, the Commissioner of Labor may, at his discretion, permit variations in the inspection requirements.
C. The inspections herein required shall be made by the Commissioner, chief boiler inspector, deputy inspector or a special inspector as provided for in the Boiler and Pressure Vessel Safety Act except that hot water supply heaters may be inspected by state-licensed boiler operators or state-licensed plumbers or plumbing contractors. The Commissioner of Labor may designate by rule the hot water supply heaters, by design type, that are not subject to inspection.
D. Owner-user inspection of boilers and pressure vessels is permitted provided the owner-user inspection service is regularly established and is under the supervision of one or more individuals whose qualifications are satisfactory to the Commissioner of Labor and the owner-user causes the pressure vessels to be inspected in conformance with the National Board Inspection Code or American Petroleum Institute Pressure Vessel Inspection Code as applicable.
F. All boilers, other than cast iron sectional boilers, and pressure vessels to be installed in this state after the twelve-month period from the date upon which the rules of the Commissioner become effective, shall be inspected during construction as required by the applicable rules by an inspector authorized to inspect boilers and pressure vessels in this state, or if constructed outside of the state, by an inspector holding a valid commission issued by the National Board of Boiler and Pressure Vessel Inspectors.
Credits
Laws 1982, c. 252, § 13; Laws 2000, c. 295, § 6, eff. Nov. 1, 2000; Laws 2016, c. 93, § 1, eff. Nov. 1, 2016; Laws 2018, c. 36, § 3, eff. Nov. 1, 2018.
40 Okl. St. Ann. § 141.13, OK ST T. 40 § 141.13
Current with emergency effective legislation through Chapter 3 of the Second Regular Session of the 59th Legislature (2024). Some sections may be more current, see credits for details.
End of Document |